The Study Of Utilization Of Steel Slag To Sabodam

Jati Iswardoyo

Abstract


Steel slag is one of the results of the rest of smelting iron ore/ steel. To reduce the abundance of steel slag, this study seeks to examine utilization as a substitute for gravel in the concrete used for construction sabodam.The durability of concrete on the outer layer was analyzed by using the results of several studies related.The most influential factor is the compressive strength of bump (impact) as a representation of the clash due to lava rock.It will be discussed about the potential use and durability. To analyze the stability of the sabodam, researcher use SNI 2851: 2015 about Sediment Retention Building Design. The parameter used is the stability of the tilting, sliding and bearing capacity. For alternative use sabodams core material, researcher used split stones and steel slagconcrete. The flood scenarios can be divided into two, namely flood plain and flood lava. Based on the results obtained, the potential for instability is found in the parameters of carrying capacity. Thesabodamwhich using split stones, the bearing capacity of the land has a minimum strength is worth -0.98 kN/m2 (for flood) and -0.43 kN/m2 (for lava flood), while sabodam with steel slag has a minimum strength of 1.74 kN/m2 (for flood) and 1.57kN/m2 (for lava flood) which means notensile stresses occured. The conclusion is the concrete with steel slag can be used as material for sabodam.

Keywords


Steel slag; Concrete; Sabodam

Full Text:

PDF

References


Ananto, Y.Z.A. (2014). Pengaruh Komposisi Steel slag Sebagai Substitusi Agregat Kasar Terhadap Ketahanan Abrasi Aliran Debris Pada Sabodam. Tugas Akhir. Universitas Islam Indonesia, Yogyakarta.

Arifah, N. (2014). Pengaruh Limbah Baja (Steel slag) Sebagai Pengganti Agregat Kasar Terhadap Kuat Tekan Beton Sabodam. Tugas Akhir. Universitas Islam Indonesia, Yogyakarta.

BSN. (2015). SNI 2851 Desain Bangunan Penahan Sedimen.

Chaurand, P. (2006). Environmental impacts of steel slag reused in road construction: Acrystallographic and molecular (XANES) approach. Journal of Hazardous Materials-5460.

Iswardoyo, J. (2014a). Penelitian Pengaruh Komposisi Steel slag Dalam Kekuatan Beton Menggunakan Uji Kuat Tekan Bentur. Prosiding Seminar Nasional Teknik Sipil X-2014. Institut Teknik Surabaya, Surabaya.

Iswardoyo, J. (2014b). Perbaikan Struktur Sabodam dengan Memanfaatkan Steel slag (Limbah Baja). Kolokium Hasil Litbang Sumber Daya Air.

Khan, R., and Shinde, S.B. (2013). Effect of Unprocessed Steel slag on Shear Strength of Concrete when used as Fine Aggregate. International Journal of IT, Engineering and Applied Sciences Research (IJIEASR) Volume 2, No. 4, April 2013.

Leksminingsih. (2007). Pengaruh Pemberian Bahan Tambah Katalis Bekas (Spent Catalyst) dan Filler Slag terhadap Campuran beton Semen untu Perkerasan Jalan. Jurnal Jalan dan Jembatan Vol.24 No 2 Agustus.166-184

Maslehuddin, M., Sharif, A.M., Shameeem, M., Ibrahim, M., and Barry, M.S. (2003), Comparison of properties of steel slag and crushed limestone agregate concretes, Construction and Building Materials 17(2003) 105-112, Elsevier diunduh dari

http://s3.amazonaws.com/academia.edu.documents/43897540/Comparison_of_properties_of_steel_slag_a20160319-30440-vkicrg.pdf?AWSAccessKeyId=AKIAJ56TQJRTWSMTNPEA&Expires=1473128331&Signature=Cp5RKUsl5hZqF9yCpYktzY3tZ7o%3D&response-content-disposition=inline%3B%20filename%3DComparison_of_properties_of_steel_slag_a.pdf

Moenir, M. dan Handayani, N.I. (2012). Recycling Limbah Padat Industri Peleburan Besi (Iron Slag) Sebagai Bahan Campuran Industri Beton Yang Berwawasan Lingkungan. Jurnal Riset Teknologi Pencegahan Pencemaran Industri. Semarang.

Mulyono, T. (2004). Teknologi Beton. Andi. Yogyakarta.

Portland Cement Association (2002). Types and Causes of Concrete Deterioration. Illinois, Unites States of America , diunduh dari

http://www.cement.org/docs/default-source/fc_concrete_technology/durability/is536-types-and-causes-of-concrete-deterioration.pdf?sfvrsn=4 ,

PT Ispat Indo. (2008). Aplikasi Pemanfaatan Steel Slag pada konstruksi Jalan, PT. Ispat Indo. Sidoarjo.

Sucofindo (2006) Report of Anaysis, Characteristic Test of Hazardous Waste, Sidoarjo, Jawa Timur

Wang, G. and Thompson, R. (2011) Slag Use in Highway Construction the Philosophy and Technology of its Utilization, International Journal of Pavement Research and Technology Vol 4. No 2. Mar 2011.

Wu, C. H., Yen, T., Liu, Y. W., and Hsu, T. H. (---) The Abrasion Erosion Resistance Of Concrete Containing Blast Furnace Slag. Taiwan Power Company Report diunduh dari http://www.nchu.edu.tw/~add/budget/student%20abroad/inter-meeting-94/T94-4-03.pdf




DOI: https://doi.org/10.32679/jth.v7i2.564

Refbacks

  • There are currently no refbacks.


Copyright (c) 2018 JURNAL TEKNIK HIDRAULIK

Indexed by:
   
     
 
 
 
Sekretariat:
 
Direktorat Bina Teknik Sumber Daya Air, Direktorat Jenderal Sumber Daya Air, Kementerian Pekerjaan Umum dan Perumahan Rakyat
 
This work is licensed under a Creative Commons Attribution-ShareAlike 4.0 International License.